12 Volt Wiring: Wire Gauge to Amps

12 Volt Wiring Gauge Requirements at specific Amps to length for Automotive Electrical Systems   …   

Wire uses the measurement of gauge to determine the size of the wire. The larger the wire, the smaller the gauge number. To find the required wire gauge for a specific application, you must know the current draw of the accessory on the circuit and the total wire length between the accessory and the power source. More current draw (higher amperage) requires a larger wire gauge to safely power the accessory.

Automotive Voltage is not 12 Volts

Automotive wiring is not exactly 12 volt. The actual resting voltage of a fully charged, 6-cell automotive lead acid battery is about 12.7 volts or about 2.1 volts per cell. 6.4 volts for a 6-volt lead-acid battery. Older batteries will probably show a lower voltage. When the vehicle is running, the alternator will increase the automotive voltage up to about 13.8 volts. 13.8 volts is a better value to use for wire gauge calculations though it will generally result in about the same gauge as 12 volts.

Resistance = Voltage Drop

With cable length comes resistance.  All wire has inherent resistance and the longer the wire, the greater the resistance and the greater the voltage drop over the length of wire.  For that reason, it is important to factor in the length of wire when determining the wire gauge.  A 3-foot wire length will have less resistance than a 20-foot wire and therefore a longer length of wire may require an increase in the wire gauge to provide adequate voltage to the accessory.  Installing too small a wire gauge decreases performance and may create a potential safety hazard.  Alternately using an oversized wire gauge does not have a downside and may provide better performance of the accessory, however, overkill in itself has the downside of wasted money and valuable space. But when choosing between two potential gauge sizes in the gray area of estimated gauge calculations or references, it’s always better to go with the larger gauge.

Choosing the Wire Gauge

To choose an adequate wire gauge, determine the amp draw (amperage) that the wire circuit will carry.  Then measure the distance that the wire will travel (length) including the length of the return to ground (the ground wire running to the chassis or back to a ground block or battery.  Using these two numbers, Amps and length, locate the nearest gauge value in the chart below.  For 6 volt automotive systems typically a wire gauge 2 sizes larger than what is shown should be used.  

@ 13.8 Volts
American Wire Gauge (AWG)
0-4 ft.4-7 ft. 7-10 ft. 10-13 ft. 13-16 ft. 16-19 ft. 19-22 ft.
35-5010-ga.10-ga.10-ga.8-ga.8-ga.8-ga.6 or 4-ga.
50-6510-ga.10-ga.8-ga.8-ga.6 or 4-ga.6 or 4-ga.4-ga.
65-8510-ga.8-ga.8-ga.6 or 4-ga.6 or 4-ga.4-ga.4-ga.
85-1058-ga.8-ga.6 or 4-ga.4-ga.4-ga.4-ga.4-ga.
105-1258-ga.8-ga.6 or 4-ga.4-ga.4-ga.4-ga.2-ga.
125-1508-ga.6 or 4-ga.4-ga.4-ga.2-ga.2-ga.2-ga.
150-2006 or 4-ga.4-ga.4-ga.2-ga.2-ga.1/0-ga.1/0-ga.
What is the difference between SWG and AWG wire gauge systems?
SWG and AWG are wire gauge systems used to represent the thickness of the wire. Different numbering systems are used depending on the type of metal. Non-ferrous metals (not containing iron) use American Wire Gauge System or AWG.    Ferrous metals generally use Standard Wire Gauge (SWG).

American Standard Wire Gauge (AWG)


Also see: 
Automotive Wiring Tips – Using Relays

12 Volt Wiring Gauge Requirements at specific Amps for Automotive Electrical Systems

12 Volt Wiring – Distance and Amps to Gauge Chart

Converting Candlepower to Watts and vice-versa & Other Offroad Light Information

Automotive Wiring Tips & Techniques

HEI Ignition Installation and Review

Using LED lights in your Vehicle

LightForce Driving Lights Install/Review

What are HID Lights?


  1. I was struggling to find info on very short runs of cable. All the other charts I’ve found rate 0-5 meters, but in my campervan build my batteries are right next to my inverter, so I couldn’t believe that I’d need giant 4AWG wiring for a 20cm run! Thanks for the great page!

    • James, thanks for the comments. Wow, 4AWG, you must have a huge inverter in that Mitsubishi Delica Campervan! Btw, really nice van you have. Looks like a really fun build!

      • Thanks Alan! Yes it’s going to have an 800w inverter. I’ll use about 500w charging my drone batteries, and another 100w for my laptop, plus a bit of overhead. Really loving the van, I’ve made a few additions (awning, new heavy duty springs etc) since my blog post and will do another write-up soon on how it’s been going. Thanks for visiting my blog 🙂

  2. That Amps-to-AWG chart is the best I’ve come across on the web so far in terms of comprehensibility. What is your source or reference? All the charts I’ve found (Wikipedia, Engineer’s Toolbox, etc.) seem to have slightly different information, so that’s why I’m curious.

    • Hi Rick. Thanks for the comments. When we put the article together, the data came from a variety of sources including companies experienced in high amp automotive wiring such as Crutchfield, engineering sources experienced in copper wiring, and some info from wiring company recommendations. All of these sources took into consideration important factors such as the wire resistance and the unique electrical systems of automobiles. We didn’t use one source directly because like you see, they do vary so we averaged from these sources to come up with our recently updated chart. Hope you find it helpful!

9 Trackbacks / Pingbacks

  1. Plug - 2014+ Jeep Cherokee Forums
  2. I need some wolo wiring help - VTXOA
  3. Axillary power distribution box fused - Suzuki Burgman Forum
  4. Relacement horn issue - Toyota Nation Forum : Toyota Car and Truck Forums
  5. 12 VDC Wiring Question.
  6. Rock Lights... What are you using
  7. long 2460 dtc - Tractor Forum
  8. A Few Aux Lighting Questions - Stromtrooper Forum : Suzuki V-Strom Motorcycle Forums
  9. Relay Wiring Question - AUX Fuse Block - JeepForum.com

Leave a Reply to Rick Cancel reply

Your email address will not be published.